The short answer
A Cowsar BC Refrigerator that has started making a noise is usually reporting one of three things: a fan blade touching frost, a compressor or relay clicking as it tries to start, or the cabinet transmitting vibration into whatever it is leaning on. Only the second of those is urgent, and it is the easiest of the three to identify.
What you see on the BC family
- A rhythmic ticking or scraping from inside the freezer — That is the evaporator fan blade touching frost, and the sound usually changes or stops when the door is opened.
- A click every few minutes from the lower back, then silence — The start relay trying and failing to start the compressor. This is the one noise on the list that needs attention quickly.
- A buzz or hum that has become noticeably louder — Often the condenser fan running against dust, or the whole cabinet resonating because it has shifted on its feet.
- A rattle that changes when you lean on the cabinet — Vibration transmitted into a cupboard, a wall or a drip tray. It is noise rather than fault.
Causes, most likely first on the BC family
- Cabinet resonance, levelling and the drip tray — Ranked first on the BC family — where the noise started after the unit was moved or cleaned behind, this is the change and nothing inside the machine has altered at all. A cabinet that has shifted on its feet rests against a cupboard or a wall and transmits ordinary compressor vibration into the joinery. A drip tray that has slipped its seat buzzes in sympathy.
- Condenser fan and a dust-loaded coil — Second — and it pairs with the cooling page: the same dust that makes this noise also makes the cabinet warm. The fan at the lower back runs whenever the compressor does, and dust on the blade or debris in its path makes it whine, buzz or tick.
- Evaporator fan blade catching frost — Third — the door test identifies it immediately and it points straight at a defrost problem underneath. Ice builds where it should not and the fan blade clips it once per revolution.
- Start relay or compressor — Fourth — a clicking relay with a warming cabinet should not be left running for days. A relay that cannot start the compressor clicks every few minutes as the overload cycles.
- Body: The order below follows the shared parts rather than the differences — the stems in the BC family carry the same running gear and diverge at the cabinet — which is why the top of this list is not where the brand-generic article puts it.
Check in this order, and why
- 1. Stand still and locate the noise before anything else — Front, inside the freezer, or lower back. Location alone removes most of the list and it costs nothing.
- 2. Time the pattern if it clicks — A click every few minutes with silence between is a start relay, and that one is urgent rather than annoying.
- 3. Open the freezer door while the noise is happening — The evaporator fan stops with the door open on most cabinets, so a noise that vanishes is that fan and a noise that continues is not.
- Body: The stems in the BC family share their layout, so the order below holds across the table; where a stem differs it differs at the cabinet, not at the part you are reaching for.
Before you open anything
Safety
Unplug the appliance or switch off its breaker before removing any panel — a capacitor can hold a charge after the power is off. A refrigerator is heavy and top-loaded when full, so empty the doors before pulling it out and keep it upright. Never put a hand near a fan blade to stop it or to feel for ice while the unit is plugged in.
Models in the BC family
Reference| Model number | Family key |
|---|---|
| BC-128-E | cowsar:refrigerator:bc |
| BC-128C-E | cowsar:refrigerator:bc |
| BC-145B | cowsar:refrigerator:bc |
| BC-145B/2T | cowsar:refrigerator:bc |
| BC-46-E | cowsar:refrigerator:bc |
| BC-46B | cowsar:refrigerator:bc |
| BC-46BC | cowsar:refrigerator:bc |
| BC-47AN | cowsar:refrigerator:bc |
| BC-70-E | cowsar:refrigerator:bc |
| BC-85B | cowsar:refrigerator:bc |
| BC-90B | cowsar:refrigerator:bc |
| BC-90U-E | cowsar:refrigerator:bc |
| BC-90VE | cowsar:refrigerator:bc |
When to call a technician
Call when the noise is a click-pause-click from the lower back, especially with a cabinet that is losing temperature, because that is a start relay or a compressor and both are service parts. Call too when a fan noise persists after the frost has thawed, since a fan that has been running against ice often has a worn bearing by then.
Other BC refrigerator pages
Lead Appliance Repair Technician · 12 years experience
Experienced technician with 12 years specializing in washing machine and dryer repairs across all major brands.
